Printronix L5520 User Manual Page 171
- Page / 244
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
171
6 Troubleshooting
Troubleshooting
This chapter discusses diagnostic tests, paper jams, and status
and error messages.
Maintaining Print Quality
To maintain good print quality, clean the printer according to the
schedules and information listed in Chapter 5.
1. Perform a General Cleaning (page 149).
NOTE: Recommended toner vacuum cleaner models are listed on
page 141.
2. Clean the main charger, precharger, and transfer charger. See
page 154 for the main charger. See page 158 for the
precharger and transfer charger.
3. If print quality problems occur, clean the following areas:
• The drum with the drum freshener (only when smears
appear on print samples due to the drum).
• The LED array and the SELFOC
lens (LED print head) with
the Toraysee cloth.
• The fuser cover glass with a razor blade or the cover glass
scraper.
If you do not set the desired print quality after cleaning the printer,
you might need to replace the chargers. Contact your authorized
service representative for further assistance.
- User’s Manual 1
- Consumables Information 2
- L5520 Multifunction Printer 3
- Software License Agreement 4
- Communication Notices 7
- Trademark Acknowledgements 10
- Table of Contents 13
- 1 Introduction 17
- Important Safety Precautions 18
- Figure 1: Printer Components 20
- September 15, 2000 21
- About The Printer 22
- Fonts And Forms 23
- Chapter 1 About The Printer 24
- 2 Initial Setup 25
- Chapter 2 Loading Paper 26
- Tractor Pins 27
- Tractor Gate 27
- Tractor Lock 27
- Powering On The Printer 29
- Using The Control Panel 31
- SYS AVAIL 32
- JOB IN PROCESS 32
- STAND BY 32
- Function Keys 33
- CLEAR Key 34
- TEST Key 34
- SHIFT Key 34
- PAGE EJECT Key 35
- ENTER Key 35
- CANCEL Key 36
- UP And DOWN Keys 36
- NEXT And PREV Keys 36
- 3 Printer Configuration 37
- Printer Configuration 40
- Factory Settings 43
- • To temporarily save the 49
- • To permanently save the 49
- Save Configuration 50
- Configuration Menus 52
- Config. Control Menu 53
- Print Configuration 54
- Delete Configuration 55
- Power-up Configuration 55
- Protect Configs 55
- Name Configs 55
- Reset Cfg Names 56
- Mode Menu 58
- Host Interface Menus 60
- Centronics Parameters 61
- Data Polarity 62
- Resp. Polarity 62
- Busy On Strobe 62
- Latch Data On 62
- Prime Signal 62
- TOF Action 63
- Buffer Size In K 63
- Dataproducts Parameters 64
- Data Protocol 68
- Baud Rate 71
- Word Length 71
- Stop Bits 71
- Data Term Ready 72
- Request To Send Function 72
- Poll Character 73
- Poll Response 73
- Idle Response 74
- One Char Enquiry 74
- Ethernet Submenu 76
- Auto Switching Parameters 77
- Auto Switching 78
- Port Type 78
- Trickle Time 78
- Report Status 79
- Etherenet Parameters Menu 80
- Etherenet Parameters Menu 81
- Paper Control Menu 82
- Fanfold Options 84
- Chapter 3 Paper Control Menu 86
- Miscellaneous Menu 88
- Power-up State 89
- Hex Dump Mode 89
- PTX SETUP Option 90
- Display Language 91
- Downloaded Fonts 91
- File System 91
- Max Cache Memory 93
- Max Cached Char 93
- Test Print Menu 94
- Print Statistics Menu 95
- DRAM Avail 96
- Flash Avail 96
- RAM Disk Avail 96
- Printer Life 96
- Maintenance Menu 97
- The lasr2fls Utility Program 99
- Downloading Into Flash Memory 101
- <Return> 107
- Flash Messages 108
- Loading Flash Memory 114
- 4 Consumables 115
- Replacing The Toner Cartridge 116
- Cartridge 119
- Waste Toner 120
- Recovery Door 120
- Toner Bottle 121
- Transfer 123
- Transfer Elavator 123
- Drive Shaft 123
- Thumbscrew 124
- Auxiliary Rod 125
- Removing The Developing Unit 129
- Developing 130
- Consumables Replacement 132
- Developing Unit Removal 133
- IMPORTANT 134
- Toner Spray 135
- Guard Brush 135
- Adding New Developer 136
- Roller Know 138
- 5 Scheduled 141
- Service Level Page Counts 142
- Maintenance Schedules 144
- User Replacement Schedule 145
- General Cleaning 149
- Chapter 5 General Cleaning 150
- Vacuuming The Printer 153
- Cleaning The Chargers 154
- Precharger/Transfer Charger 158
- Major Cleaning 164
- Chapter 5 Major Cleaning 166
- Discharge 167
- Caherger 169
- Cleaning The SELFOC 170
- 6 Troubleshooting 171
- Offline Diagnostics 172
- Online Diagnostics 172
- Paper Jams 173
- Chapter 6 Paper Jams 174
- Transfer Elevator 175
- Elevator Drive 179
- Disabled 183
- Standby 183
- Clearing Fault 183
- Faults Not Cleared 183
- Reload Paper 184
- Not Reprinting 184
- Failed Pages 184
- Clear Paper Path 185
- Reprinting 186
- Error Messages 187
- TABLE NOTES: 194
- A Maintenance Log 197
- Appendix A 198
- 600,000 Pages (Service) 201
- 900,000 Pages (Service) 202
- 1,200,000 Pages (Service) 202
- WARNING 203
- B Specifications 205
- Performance Characteristics 208
- Host Interfaces 209
- Emulations 209
- Memory Requirements 210
- Environment 211
- Temperature (5F) 212
- C Host I/O Interfaces 213
- Host I/O Interfaces 214
- Performance Considerations 215
- RS-232 Serial Interface 217
- RS-422 Serial Interface 220
- Centronics Parallel Interface 224
- Assignments 225
- Termination Resistors 231
- RINTRONIX, INC 244
- RINTRONIX 244
- RINTRONIX Schweiz GmbH 244
Related products and manuals for Printers Printronix L5520
Printers Printronix L5035 User Manual
(278 pages)
(278 pages)
Printers Printronix T5000R User Manual
(96 pages)
(96 pages)
Printers Printronix Series 5 User Manual
(248 pages)
(248 pages)
Printers Printronix L1024 User Manual
(136 pages)
(136 pages)
Printers Printronix L5020 User Manual
(248 pages)
(248 pages)
Printers Printronix LQH-HWTM User Manual
(302 pages)
(302 pages)
Printers Printronix P7000HD User Manual
(44 pages)
(44 pages)
Printers Printronix P5000 User Manual
(2 pages)
(2 pages)
Printers Printronix L5535 User Manual
(180 pages)
(180 pages)
Printers Printronix SL5000e User Manual
(52 pages)
(52 pages)
Printers Printronix P5000LJ Series User Manual
(336 pages)
(336 pages)
Printers Printronix T3306 User Manual
(144 pages)
(144 pages)
Printers Printronix H-SERIES P7000 User Manual
(210 pages)
(210 pages)
Printers Printronix P9000 Series User Manual
(334 pages)
(334 pages)
Printers Printronix SL5000r MP User Manual
(84 pages)
(84 pages)
© 2020, manymanuals.com. All rights reserved. | 1.488 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals